Talk:Equipment for autonomous growth

Open Issue: "abstain from any electronics"

• Is it possible to abstain from any electronics on Mars? This is an essential question as it may decide about the technological long term stability of a Martian colony.

• I'm not even sure what the question means, can you please elaborate? Peter 20:17, 25 November 2007 (UTC)

• I think what is meant (Rfc, correct me if I'm wrong) is that is it possible for colonists to live in an established colony (I can't even remotely see how this is possible for early settlements) with the bare minimal of electronics (apart from life-support systems I assume) - a minimalist existence (akin to "Areophany" as established by the character Hiroko in the novel Red Mars)? -- Ioneill 22:08, 25 November 2007 (UTC)

Please let me explain a little. What mean is not to abstain from any automation on Mars, only abstain from electronics. The things we are used to do with electronics are not really bound to the flow of electrons and the creation of semiconductors. Moreover, you can do automation with exactly the same functionality and precision by means of pneumatics for example. I have learned this during my apprenticeship many years ago. We have constructed complex circuits with flowing air instead of flowing electrons. This technology seems to be almost forgotten, and people tend to think of electronics as the only way of doing automation. Here on Earth it is easy to go to the electronics merchant and buy a handful of transistors and rectifiers. But on Mars? I am afraid the settlers can not afford to build a transistor factory with all the costly technology required for making a transistor out of sand. May be it will be possible some day, but perhaps not now. This applies consequently for silicon based solar panels, also. And it might be hard to maintain a communication link between Mars and Earth, for it might be impossible to build an electronic radio transmitter. Sure, we will use electronics during the initial installation of the first settlement, but this is not what I mean with this open issue. Instead, I mean the autonomous growth afterwards.

What I intend with this open issue is to pose this problem and to make people think about possible alternatives. May be it is possible to build a transistor factory on Mars, may be it is not. In the latter case we need an alternative, or else we have no autonomous settlement. -- Rfc 08:31, 26 November 2007 (UTC)

Computer power is increasing exponentially, so I don't think it makes sense to build heavy and complex air based "computers". A computer the size of a cellphone at the time when Mars is being colonized will be as fast as todays supercomputers.. At first most computers will be transported from Earth, but at some point they will be fabricated on Mars. Obviously, complex technology like this will be the last things to be fabricated on Mars. However, computers are really lightweight, so I don't see this as a problem. Nawi 11:53, 1 July 2008 (UTC)

The weight is not the point. The effort for reproduction is the point. A Martian colony is not autonomous if reproduction of such a computer is not possible. -- Rfc 20:06, 2 July 2008 (UTC)

A martian colony does not have to 100% autonomous from the start. Using air pipes etc for automation would make a really inefficient and bad Martian colony. Nawi 11:10, 3 July 2008 (UTC)

Pneumatic data processing is used on Earth where the interface between pneumatic and electronic systems would be an added complication, and the needed data processing is simple enough. Data processing is used wastefully on Earth because megaflops are cheap. If only the necessary data processing for automation is done, pneumatic, hydraulic, or other fluidic data processing is an alternative. - Farred 15:59, 9 November 2012 (UTC)

Even if the goal is only economic rather than complete physical self-sufficiency -- and commerce won't invest in it without economic self-sufficiency plus profit -- and even if there are many lucrative exports, we will still have strong incentives to achieve almost complete physical self-sufficiency, to minimize the mass of imports from Earth. It costs over $100,000/kg to get stuff to the Martian surface from Earth. That cost has not fallen very much since the Viking lander in 1976. Even with two orders of magnitude reduction in cost by the time we start the colony, it will still cost a dollar a gram to import anything from Earth, and it will all have to be paid for by exports. So sure, we can have sophisticated electronics -- but they will be confined to gram-sized chips and sensors and wireless connections and software. We have to interface these Earth chips with crude machines made by craftsmen using other crude machines, which may lack any other kinds of electronics whatsoever. Making equipment in a tiny economy, rather than in Earth's global economy with its billions of diverse workers who make billions of different kinds of sophisticated parts, requires a radical redesign of every single piece of equipment. Frontiersman 13:54, 12 February 2010 (UTC)

vacuum tube technology could be produced on Mars and is an option to consider. There have been considerable inovations in vacuum tube technology such as carbon nanotube cold cathode diodes. Carbon nanotubes for this purpose could be produced as soot is produced. It might be suitabel for Mars.--Farred 00:18, 15 February 2010 (UTC)

I think that's a good idea, a good direction to explore, but be sure to account for all the different materials used in a vacuum tube.Frontiersman 01:46, 15 February 2010 (UTC)

Shared components

Is it posible to have all infrastructure on Mars constructed out of shared components? For example, uniform sizes of nuts, bolts, ball bearing, etc. This would eliminate overcomplexity in factories. Systems inside factries could use these componoents, a factory could "reproduce" if automated. Transistiors and other computer "hardware" equipment could be created using something like a 3-d printer, all that would differ would be the software. This allows a base to grow along with its population. T.Neo 11:35, 1 July 2008 (UTC)

Great idea! Go write it:-) -- Rfc

Re: Example: Repair of solar panels

An alternative to solar panels is solar thermal electric generation. The mirrors would need to be designed to withstand Martian wind storms, which are another aspect of the dust storms, or be sheltered during a storm. The steam condensing coils would be more difficult to cool in the thin atmosphere. However, there is a dependable low atmospheric temperature, so a big chimney might provide enough draft, something like a cooling tower for a nuclear power plant on Earth.

The months long dust storms would be a problem that would require some sort of power storage to meet the reduced power requirements for waiting out the storm.

The many things that a self reproducing colony ought to do would affect the minimum size of a self reproducing colony. I am nowhere close to putting a number on that size.

On the road to a self reproducing colony, an imported nuclear power plant could fulfill power needs. The plan for the self reproducing colony should be in hand when the first colonist sets out from Earth. Then regular colonist transportation would be needed until the planned size is fulfilled. - Farred 15:46, 9 November 2012 (UTC)

Solar thermal electric generation: Fascinating idea! We should write an article about it. Could be less prone to degradation due to cosmic radiation and UV.

Energy storage: There is an article about this already (energy storage).

Nuclear power: I don't like the idea, because the radioactive waste disposal is an unresolved problem as yet. This is true for both Earth and Mars. I better like the plan of Mars One, that provides all needed power from thin-film photovoltaic modules, which seems to be possible right from the start. -- Rfc 16:31, 9 November 2012 (UTC)

I would like to write an article on solar thermal electric generation myself, I can add it to my list. Like a number of articles on my list it would take considerable work including library research that I do only with difficulty. Instead I do things that are easy and consume my time, like removing spam and writing easy comments on talk pages. The spam is a discouraging waste of time, truly a plague on Lunarpedia.

I do not see any problem with disposing of nuclear waste on Mars. On Earth there is concern that leaking containers could contaminate ground water. On Mars people would need to look hard to find a place where there is ground water to contaminate. Probably there is some wet water under the polar ice caps where it was melted by planetary heat and slowly flows to the edge where it reaches the surface and evaporates and freezes. Any other place a pit could be dug and spent fuel elements laid in it. Cover them with a couple meters of regolith, concrete and a warning notice and they will harmlessly stay there for a thousand years. What is the problem? After a hundred years the radioactivity will have decreased enough to make reprocessing for new fuel rods relatively easy. A full uranium mining and enrichment industry is unneeded. You advocate solar power which is very expensive. It seems to me the problem is emotional, fear that is not based upon fact. If contributors to Marspedia mostly want nuclear power ruled out, it is the prerogative of the majority to have its way. - Farred 13:57, 13 November 2012 (UTC)

Certainly mistakes in engineering which allow accidents to cause nuclear contamination problems are a serious concern, but less so on Mars then on Earth. The habitat should be protected from nuclear contamination. The outside is full of radiation naturally from cosmic rays, the solar wind and coronal mass ejections. A nuclear leak to the outside would seem minor. To worry about the possibility of a nuclear accident on Mars and calmly accept the constant ambient radiation threat seems to me like straining out the gnat and swallowing the camel. - Farred 14:14, 13 November 2012 (UTC)

My idea of the best sort of power generation from the start of the colony on Mars to a period of steady expansion is in a number of steps. First use solar power and batteries. Next assemble a nuclear reactor with mostly local materials but fuel rods and other critical parts sent from Earth. The nuclear power will serve for periods without sunshine relegating energy storage to emergency use status. It would serve when nuclear power would be off line. Reducing the need for energy storage would make expansion of the electrical power system cheaper, so the colony as a whole could expand faster than otherwise. When the fuel rods reach maximum design burn up, they would be stored as I stated above. Replacement fuel rods would be sent from earth. This is a greater energy density in the mass transported than solar cells. After many years of colony growth and a few sets of fuel rod replacements, Mars would begin to reprocess old fuel rods for new, getting much more energy out of the fuel rods than is possible without reprocessing. The use of nuclear power for times without sunshine could increase as the size of the colony increases. It seems to me that if people put too many restrictions on how industry on Mars can develop, the development might become practically impossible and that time when industry can be devoted to terraforming will never be reached. I can not prove that this is so, but there are certainly difficulties in developing an electrical power system for a vast industry on Mars. There is no oxygen atmosphere in which to burn things like coal, and likely no coal. An ambitious goal of expanding a Mars colony requires some plan for a source of energy. Without such a plan, a Mars colony would be constantly small and dependant upon Earth. Terraforming would never be an option.

I am in a peculiar position on this wiki as a member of the Moon Society and not the Mars Society I would like to see a Mars colony progressing on a plan which is sufficient that it succeed in the long term but my viewpoint is different is some respects from members of the Mars Society in general. As a guest administrator, I would not want to oppose members of the Mars Society in anything I would put into an article. - Farred 00:44, 16 November 2012 (UTC)

The difficulty with the plan of Mars One is that it lacks any details as to when or how the colony will be self sufficient or expand. It seems to be based upon the assumption that no plan is necessary because the requirements are so simple that we can work out the problems once we have people on Mars. I disagree. I quote myself: "The plan for the self reproducing colony should be in hand when the first colonist sets out from Earth." The economics of a self reproducing colony on Mars is an extremely complex thing to be worked out in advance so that mistakes are not made in establishing industries in an inefficient order or having a Mars colony unnecessarily dependent upon Earth for a significant time. - Farred 08:22, 16 November 2012 (UTC)

Mars One seems to be working on plans. I thought the plans that I had seen previously were too sketchy to settle upon a date for sending the first manned mission to Mars. Recently I read what Mars One wrote about: "What’s keeping us busy?" First on the list was: "Preparations for the Conceptual Design Studies". It might have been better to have conceptual design studies before setting a date for landing men on Mars, but better late than never. The schedule might need to be delayed as they find out how difficult a problem they are facing. - Farred 09:17, 16 November 2012 (UTC)

I disagree about the cost of nuclear energy. The assumption that nuclear energy is cheaper than solar energy is simply wrong. And again, this is true for both Earth and Mars. I had a look at some interesting figures about research, development, safety and maintenance costs as well as subsidy facts of several sorts of energy, including fossil, nuclear and renewable energy. The result was that nuclear energy is by far the most expensive energy. If you had added all those expenses to the consumer price you are paying per kWh, you would pay nearly 2 USD per kWh. And this does not even include the cost for the final disposal. I am afraid, the nuclear power advocacy group is not really interested in spreading the truth about those costs. In contrast, the R&D costs for solar, wind, biomass etc. energy has been only a tenth. 20 cents per kWh is now a reality, with a strong tendency to drop further.

You may argue that the nuclear technology is now available and established, so no further investment may be necessary for research and development. This might be true if the colony was on Earth. The Martian conditions, however, require different colling systems, different logistics, different housings, different heat flow processes. And the most important difference is the size. While nuclear power plants on Earth are big and heavy (with big and heavy critical components), the plant for a 10000 person settlement would be rather small. The bigger the plant is, the more efficient it works with regards to the costs. Simple economics. It just does not scale down linear.

By the way, can you imagine the protests from the terrestrial people if the nuclear fuel rods are launched for transport to Mars? They will argue that the rocket may explode and contaminate Earth's atmosphere.

All these thoughts come to me, when I start thinking of powering a Martian colony with nuclear energy. I have no intention of retarding the Martian development due to some diffuse fear. I think that nuclear energy is not viable because of unagitated calculation.

Sure, energy is a critical issue for expansion of the colony. It certainly sets a limit. May be, someday the use of nuclear energy will be cheap and safe, thanks to some future inventions. The settlers may decide for themselves.

Any idea, even nuclear, is welcome on Marspedia, for my understanding. I see Marspedia as a collection of facts and ideas. It would be wrong to draw a lopsided picture of a Martian colonization. Several concepts may (and should!) be outlined. Only, each outline should be realistic and described with full range considerations. After all, I don't see much difference between Mars and Moon regarding energy.

And yes, I see a lack of concepts for further development in Mars One, too. Mars One seems to plan the initial installation with pure non-autonomous technology. I was somehow irritated in the first moment. But then it occurred to me that this is the fastest way of establishing a Martian settlement, thus being the only realistic way of starting. No matter what comes after that, the first step is done, and as soon as there are people on Mars, they will stay there by all means. This is because it will always be cheaper to keep them alive over there than to bring them back to Earth. The human genius will then, step by step, aim to make the Martian settlement more and more self sufficient. There is a lot hope in it, of course. -- Rfc 19:58, 18 November 2012 (UTC)